Study of the structure of organo-modified palygorskite

Authors

DOI:

https://doi.org/10.15587/2312-8372.2017.112900

Keywords:

palygorskite, hexadecyltrimethylammonium bromide, cationic surfactant, Cr(VI) adsorption

Abstract

The object of research is a natural silicate with a layer-band structure - palygorskite of the Cherkasy deposit (Ukraine). One of the problematic areas in the technology of sorption purification of aqueous media using palygorskite is the absence of kinship of the mineral in anionic forms of pollution. Therefore, its use as a sorbent to extract ions Cr(VI), U(VI), As(V), which are in aqueous media in anionic forms, is ineffective.

In the course of the study, XRD methods, thermal analysis and a spectrophotometric method are used to study the sorption properties of synthesized materials.

The structures of palygorskite and modified samples are studied using -ray diffraction analysis (XRD). After treatment with Na-PG, changes in its crystal structure are observed. There is a shift of the peaks toward large angles 2θ. Comparison of the diffractograms OPG-1 and OPG-2 allows to conclude that the reflection with the same indices is not relatively displaced, but their intensity is different. In OPG-2, the intensity of most peaks is higher.

The thermal properties of palygorskite and the resulting composites are studied. According to the results of sorption studies, it is established that palygorskite modified at a ratio of CEC/surfactant=1 can remove up to 97.8 % of Cr(VI) ions. This is 16.2 times more than adsorbing natural palygorskite.

As a result of studies of the Cr(VI) adsorption on Na-PG, OPG-1 and OPG-2, it has been shown that modifying the palygorskite surface by GDTMA can increase the adsorption of Cr(VI) from 0.45 mg/g and 9.2 mg/g, respectively. And for the initial concentration of the solution is 100 mg/l to 4.2 and 12.3 mg/l, respectively.

Increasing the volume of practical use of natural silicate materials contributes to a comprehensive solution of environmental issues, resource saving and technology for the production of sorbents for the extraction of anionic forms of Cr(VI) and U(VI) from aqueous solutions.

Author Biography

Nataliya Zhdanyuk, National Technical University of Ukraine «Igor Sikorsky Kyiv Polytechnic Institute», 37, Peremogy ave., Kyiv, Ukraine, 03056

Assistant

Department of Chemical Technology of Ceramics and Glass

References

  1. Holembiovskyi, A. O., Kovalchuk, I. A., Kornilovych, B. Yu., Zhdanyuk, N. V. (2011). Vyluchennia spoluk U(VI) z vod iz vykorystanniam orhanohlyny. Naukovi visti NTUU «KPI», 6, 154–158.
  2. Tarasevych, Yu., Ovcharenko, F. (1975). Adsorbtsiia na glinistyh mineralah. Kyiv: Naukova dumka, 351.
  3. Bergaya, F., Theng, B. K. G., Lagaly, G. (2006). Handbook of Clay Science, Vol. 1. Elsevier, 1246.
  4. Swarnakar, V., Agrawal, N., Tomar, R. (2011). Sorption of Cr (VI) & As (V) on HDTMA – Modified Zeolites. International Journal of Scientific & Engineering Research, 2 (5), 1–9.
  5. Xu, S., Boyd, S. A. (1995). Cationic Surfactant Sorption to a Vermiculitic Subsoil via Hydrophobic Bonding. Environmental Science & Technology, 29 (2), 312–320. doi:10.1021/es00002a006
  6. Mittal, V., Herle, V. (2008). Physical adsorption of organic molecules on the surface of layered silicate clay platelets: A thermogravimetric study. Journal of Colloid and Interface Science, 327 (2), 295–301. doi:10.1016/j.jcis.2008.08.036
  7. Anderson, M. A., Trouw, F. R., Tam, C. N. (1999). Properties of Water in Calcium- and Hexadecyltrimethylammonium-Exchanged Bentonite. Clays and Clay Minerals, 47 (1), 28–35. doi:10.1346/ccmn.1999.0470103
  8. Majdan, M., Pikus, S., Rzaczynska, Z., Iwan, M., Maryuk, O., Kwiatkowski, R., Skrzypek, H. (2006). Characteristics of chabazite modified by hexadecyltrimethylammonium bromide and of its affinity toward chromates. Journal of Molecular Structure, 791 (1-3), 53–60. doi:10.1016/j.molstruc.2005.12.043
  9. Li, Z., Willms, C. A., Kniola, K. (2003). Removal of Anionic Contaminants using Surfactant-modified Palygorskite and Sepiolite. Clays and Clay Minerals, 51 (4), 445–451. doi:10.1346/ccmn.2003.0510411
  10. Zhdanyuk, N., Bykov, O. (2017). Characteristics of o rganofilized palygorskite and of its affinity toward chromates. Bulletin of NTU «KhPI». Series: Mechanical-technological systems and complexes, 19 (1241), 11–16.
  11. Sarkar, B., Xi, Y., Megharaj, M., Krishnamurti, G. S. R., Rajarathnam, D., Naidu, R. (2010). Remediation of hexavalent chromium through adsorption by bentonite based Arquad® 2HT-75 organoclays. Journal of Hazardous Materials, 183 (1-3), 87–97. doi:10.1016/j.jhazmat.2010.06.110
  12. Zhdanyuk, N. V. (2017). Adsorbtsiia ioniv Cr (VI) ta Co (II) palyhorskitom modyfikovanym kationnymy poverkhnevo-aktyvnymy rechovynamy. Vestnik Odesskogo natsionalnogo universiteta, 22(3 (63)), 73–78.
  13. Lurie, Yu. Yu. (1989). Analiticheskaia himiia promyshlennyh stochnyh vod. Moscow: Khimiia, 448.
  14. Ivanova, V. P., Kasatov, B. K., Krasavina, T. N., Rozinova, E. L. (1974). Termicheskii analiz mineralov i gornyh porod. Leningrad: Nedra, 399.
  15. Yariv, S., Cross, H. (2001). Organo-Clay Complexes and Interactions. CRC Press, 680.

Downloads

Published

2017-09-21

How to Cite

Zhdanyuk, N. (2017). Study of the structure of organo-modified palygorskite. Technology Audit and Production Reserves, 5(3(37), 4–8. https://doi.org/10.15587/2312-8372.2017.112900

Issue

Vol. 5 No. 3(37) (2017): Chemical Engineering

Section

Chemical and Technological Systems: Original Research

License

Copyright (c) 2017 Nataliya Zhdanyuk

Creative Commons License

This work is licensed under a Creative Commons Attribution 4.0 International License.

The consolidation and conditions for the transfer of copyright (identification of authorship) is carried out in the License Agreement. In particular, the authors reserve the right to the authorship of their manuscript and transfer the first publication of this work to the journal under the terms of the Creative Commons CC BY license. At the same time, they have the right to conclude on their own additional agreements concerning the non-exclusive distribution of the work in the form in which it was published by this journal, but provided that the link to the first publication of the article in this journal is preserved.