Comparative analysis of the characteristics of insulating vegetable liquids for high voltage electrical equipment

Authors

  • Володимир Борисович Абрамов National Technical University of Ukraine «Kyiv Polytechnic Institute», Prospect Peremohy, 37, Kyiv-56, Ukraine, 03056, Ukraine https://orcid.org/0000-0003-3509-4804
  • Олександр Ростиславович Проценко National Technical University of Ukraine «Kyiv Polytechnic Institute», Prospect Peremohy, 37, Kyiv-56, Ukraine, 03056, Ukraine https://orcid.org/0000-0002-7719-3336

DOI:

https://doi.org/10.15587/2312-8372.2016.72899

Keywords:

insulating vegetable liquids, aging, moisturizing, flatulence, insulators of high-voltage electrical equipment

Abstract

This is a summary of investigations of influence of raw vegetable materials on the characteristics of liquids which can be used as an insulator in high voltage electrical equipment. Raw materials influence not only the initial characteristics of produced liquids, but also on changes in these parameters while they're being used. In presenting the results of research attention is given to achieving the desired characteristics of the thermo-oxidative stability of such liquids, the differences of the aging process in which paper insulation, possibilities of diagnostics of defects on the basis of gasification equipment control. It is noted that the use of different vegetable raw materials leads to differences in the manufacturing process and use of these liquids. Among the positive effects of the use of insulating vegetable liquids in high-voltage electrical equipment, one can note an increase in durability of cellulose insulation in them. However, usage of such equipment will require development and application of techniques for its control which differ from those which are conventionally used for mineral oils.

Author Biographies

Володимир Борисович Абрамов, National Technical University of Ukraine «Kyiv Polytechnic Institute», Prospect Peremohy, 37, Kyiv-56, Ukraine, 03056

Candidate of Technical Sciences, Associate Professor

Department of High Voltage Engineering And Electrophysics

Олександр Ростиславович Проценко, National Technical University of Ukraine «Kyiv Polytechnic Institute», Prospect Peremohy, 37, Kyiv-56, Ukraine, 03056

Candidate of Technical Sciences, Associate Professor

Department of High Voltage Engineering And Electrophysics

References

  1. Abramov, V., Protsenko, O., Trotsenko, Ye. (2016). Overview of alternative replacement of insulating oil in high voltage electrical equipment. Technology Audit And Production Reserves, 1(1(27)), 42–49. doi:10.15587/2312-8372.2016.59617
  2. Oommen, T. V. (2002, January). Vegetable oils for liquid-filled transformers. IEEE Electrical Insulation Magazine, Vol. 18, № 1, 6–11. doi:10.1109/57.981322
  3. Fofana, I. (2013, September). 50 years in the development of insulating liquids. IEEE Electrical Insulation Magazine, Vol. 29, № 5, 13–25. doi:10.1109/mei.2013.6585853
  4. Fofana, I., Wasserberg, V., Borsi, H., Gockenbach, E. (2002, May). Challenge of mixed insulating liquids for use in high-voltage transformers. 1. Investigation of mixed liquids. IEEE Electrical Insulation Magazine, Vol. 18, № 3, 18–31. doi:10.1109/mei.2002.1014964
  5. Wilhelm, H. M., Stocco, M. B. C., Tulio, L., Uhren, W., Batista, S. G. (2013, August). Edible natural ester oils as potential insulating fluids. IEEE Transactions on Dielectrics and Electrical Insulation, Vol. 20, № 4, 1395–1401. doi:10.1109/tdei.2013.6571461
  6. Obande, J. O., Agber, J. U. (2014, June). Palm Oil As An Alternative Dielectric Transformer Coolant. International Journal of Research in Engineering and Science, Vol. 2, № 6, 8–13.
  7. Matharage, B. S. H. M. S., Fernando, M. A. R. M., Bandara, M. A. A. P., Jayantha, G. A., Kalpage, C. S. (2013, June). Performance of coconut oil as an alternative transformer liquid insulation. IEEE Transactions on Dielectrics and Electrical Insulation, Vol. 20, № 3, 887–898. doi:10.1109/tdei.2013.6518958
  8. Martins, M. (2010, November). Vegetable oils, an alternative to mineral oil for power transformers- experimental study of paper aging in vegetable oil versus mineral oil. IEEE Electrical Insulation Magazine, Vol. 26, № 6, 7–13. doi:10.1109/mei.2010.5599974
  9. Carcedo, J., Fernández, I., Ortiz, A., Delgado, F., Renedo, C. J., Pesquera, C. (2015, November). Aging assessment of dielectric vegetable oils. IEEE Electrical Insulation Magazine, Vol. 31, № 6, 13–21. doi:10.1109/mei.2015.7303258
  10. Li, J., Zhang, Z., Zou, P., Grzybowski, S., Zahn, M. (2012, September). Preparation of a vegetable oil-based nanofluid and investigation of its breakdown and dielectric properties. IEEE Electrical Insulation Magazine, Vol. 28, № 5, 43–50. doi:10.1109/mei.2012.6268441
  11. Mendes, J. C., Reis, A. S. G., Nogawa, E. C., Ferra, C., Martins, A. J. A. L., Passos, A. C. (2008). Advanced application of a natural ester vegetable oil in a HV power transformer. CIGRE, Paper A2-101. Available: https://library.e.abb.com/public/d9c7f1ba8834e4adc12577bb0037033c/Cigre%20Session%20Paper.pdf
  12. Domingos, A. K., Saad, E. B., Vechiatto, W. W. D., Wilhelm, H. M., Ramos, L. P. (2007, April). The influence of BHA, BHT and TBHQ on the oxidation stability of soybean oil ethyl esters (biodiesel). Journal of the Brazilian Chemical Society, Vol. 18, № 2, 416–423. doi:10.1590/s0103-50532007000200026
  13. IEEE Std C57.147-2008. IEEE Guide for acceptance and maintenance of natural ester fluids in transformers. (2008). New York, USA, 1–31. doi:10.1109/ieeestd.2008.4566080
  14. BS EN 60814:1998. Insulating liquids. Oil-impregnated paper and pressboard. Determination of water by automatic coulometric Karl Fischer titration. (15.02.1998). Available: http://dx.doi.org/10.3403/01317331
  15. BS EN 61198:1994. Mineral insulating oils. Methods for the determination of 2-furfural and related compounds. (15.06.1994). Available: http://dx.doi.org/10.3403/00334970
  16. BS EN 60450:2004. Measurement of the average viscometric degree of polymerization of new and aged cellulosic electrically insulating materials. (16.08.2004). Available: http://dx.doi.org/10.3403/03097667
  17. Rapp, K. J., McShane, C. P., Luksich, J. (2015). Interaction mechanisms of natural ester dielectric fluid and kraft paper. IEEE International Conference on Dielectric Liquids, 2005. Institute of Electrical & Electronics Engineers (IEEE), 393–396. doi:10.1109/icdl.2005.1490108
  18. Bertrand, Y., Laurichesse, D. (2007). Comparison of the oxidation stabilities of vegetable based and mineral insulating oils. MatPost. Lyon, France. Available: http://2011.matpost.org/matpost2007/docs/MATPOST07_0058_paper.pdf
  19. Mulej, M., Varl, A., Končan-Gradnik, M. (2004). Up-to-date experience on furans for transformer diagnostics. High voltage engineering, 6.
  20. Shchutenko, O. V., Abramov, V. B., Baklai, D. N. (2013). Analis problem, vosnikaiushih pri interpretatsii resul'tatov hromatograficheskogo analisa rastvorennyh v masle gasov. Visnyk NTU «KhPI». Enerhetyka: nadiinist i enerhoefektyvnist, 59 (1032), 164–180.
  21. BS EN 60599:2016. Mineral oil-filled electrical equipment in service. Guidance on the interpretation of dissolved and free gases analysis. (31.01.2016). Available: http://dx.doi.org/10.3403/30285370
  22. ASTM D2780-92(1997). Standard Test Method for Solubility of Fixed Gases in Liquids. Available: http://dx.doi.org/10.1520/d2780-92r97

Downloads

Published

2016-07-26

How to Cite

Абрамов, В. Б., & Проценко, О. Р. (2016). Comparative analysis of the characteristics of insulating vegetable liquids for high voltage electrical equipment. Technology Audit and Production Reserves, 4(1(30), 56–62. https://doi.org/10.15587/2312-8372.2016.72899

Issue

Vol. 4 No. 1(30) (2016): Mechanical engineering and machine building. Energy, energy-saving technologies and equipment

Section

Electrical Engineering and Industrial Electronics: Original Research

License

Copyright (c) 2016 Technology audit and production reserves

Creative Commons License

This work is licensed under a Creative Commons Attribution 4.0 International License.

The consolidation and conditions for the transfer of copyright (identification of authorship) is carried out in the License Agreement. In particular, the authors reserve the right to the authorship of their manuscript and transfer the first publication of this work to the journal under the terms of the Creative Commons CC BY license. At the same time, they have the right to conclude on their own additional agreements concerning the non-exclusive distribution of the work in the form in which it was published by this journal, but provided that the link to the first publication of the article in this journal is preserved.