Determining the speed and acceleration of the separator for grass leaf part in horizontal and vertical directions
DOI:
https://doi.org/10.15587/1729-4061.2021.242957Ключові слова:
vitamin-grass flour, high-temperature drying of grass, separator of hay leaves, sieve speed, sieve accelerationАнотація
Vitamin-grass flour is the main component of mixed fodders intended for all types of livestock and poultry. Earlier and currently, the vitamin-grass flour has been prepared from legumes by a high-temperature drying technique. However, existing techniques have high operating costs and require very expensive technical tools.
To reduce the specific operating costs and the price of equipment in the production of VGF, a technique has been proposed that involves the main drying of grass to a moisture content of 30‒35 % on a swath while the post-drying of grass is performed in a small-sized channel under the haystack without air heating. Next, the dried mass is pre-crushed. At the same time, the delicate leaf part of the hay, while falling between the side walls of hammers and counter-hammers, is ground and finely crushed, and the stems are processed into large fractions. From pre-crushed hay, the leaf part is separated and fed into the crusher to produce flour.
In this case, the main machine that determines the performance of the line is the separator of the leaf part of the grass.
The results of the theoretical research have established the speed and acceleration of hay movement on the surface of the sieve. These values determine the productivity of separation of the leaf part from pre-crushed hay and the reliability of the selected structural and technological scheme of the separator. The production tests have confirmed the reliability and economic efficiency of the proposed technique. Comparing the proposed technique for obtaining vitamin-grass flour by existing high-temperature methods has shown that the carotene content in flour was 1.6 times higher while the specific operating costs and equipment price were 6‒7 times lower
Спонсор дослідження
- Авторы статьи выражают благодарность Голикову Владимиру Андреевичу, академику НАН РК; Найденко Е.В., Смагулову Т.А., Ни З.Н. Вышеперечисленные сотрудники являются членами исследовательской группы и внесли весомый вклад при проведении экспериментальных исследований и производственных испытаний. Финансирование работы было осуществлено по бюджетной программе 055 МОН РК по проекту «Разработка технологии и линии приготовления витаминно-травяной муки из листовой части трав, обеспечивающей снижение удельных эксплуатационных затрат». Авторы статьи также выражают благодарность сотрудникам Комитета по науке МОН РК, которые обеспечивали непрерывное финансирование проекта в течение 2012–2014 гг.
Посилання
- Nikitina, T. K. (2000). Korma i kombikorma. Sankt-Peterburg: OOO «Respeks», 256.
- Kirenkov, L. I. (1985). Spravochnik mehanizatora-zhivotnovoda. Moscow: Rossel'hozizdat, 367.
- Sukhanova, E. V. (2020). The use of vitamin-herbal flour from sainfoin sandy to increase the productivity of lactating cows and the safety of calves of the dairy period in the perm region. Izvestia Orenburg State Agrarian University, 6 (86), 291–294. doi: https://doi.org/10.37670/2073-0853-2020-86-6-291-294
- Bacanov, I. N., Smirnov, A. I., Salmanis, A. Ya., Kirenkov, L. I., Antrapovskiy, N. M. (1974). Spravochnik mehanizatora-zhivotnovoda. Moscow: Rossel'hozizdat, 400.
- Kulakovskiy, I. V., Kirpichnikov, F. S., Reznik, E. I. (1987). Mashiny i oborudovanie dlya prigotovleniya kormov. Ch. 1. Moscow: Rossel'hozizdat, 285.
- Liniya po proizvodstvu vitaminno-travyanoy muki. Available at: https://agroru.com/doska/liniya-po-proizvodstvu-vitaminno-travyanoj-muki-756269.htm
- Zykov, A. V., Zakharov, A. M., Yunin, V. A. (2019). Infrared method for drying vegetable raw materials. Journal Of Advanced Research In Technical Science, 16, 107–110. doi: https://doi.org/10.26160/2474-5901-2019-16-107-110
- Yunin, V. A., Zykov, A. V., Zakharov, A. M., Perekopsky, A. N. (2020). Research of drum installation of drum type with infrared heat source. International Research Journal, 6 (96), 64–68. doi: https://doi.org/10.23670/IRJ.2020.96.6.010
- Morozkov, N. A., Terentyeva, L. S., Sukhanova, E. V., Voloshin, V. A. (2021). Vitamin-herbal flour from Rhaponticum carthamoides in the diets of dairy cows. Agricultural Science Euro-North-East, 22 (4), 570–580. doi: https://doi.org/10.30766/2072-9081.2021.22.4.570-580
- Tabakov, N. A. (2018). Vitaminno-travyanaya muka v proizvodstve kombikormov Kraya. Materialy II Mezhdunarodnoy nauchno-prakticheskoy konferencii «Nauchnoe obespechenie zhivotnovodstva Sibiri». Krasnoyarsk, 35–39. Available at: http://niizh.krasn.ru/wp-content/uploads/2018/05/conf17-18_05_2018.pdf
- Leuta, I. A. (2016). Obosnovanie effektivnosti organizacii proizvodstva granul iz vitaminno-travyanoy muki. Sb. tr. Mezhd. (zaochnoy) nauchno-prakt. konf. «Ekonomika i upravlenie v sovremennyh usloviyah». Krasnoyarsk, 145–150.
- Leuta, I. A. (2015). Proizvodstvo vitaminno-travyanoy muki - vostrebovanniy vysokodohodniy biznes. Sb. tr. Mezhd. (zaochnoy) nauchno-prakt. konf. «Ekonomika i upravlenie v sovremennyh usloviyah». Krasnoyarsk, 130–132.
- Nurlybaev, Қ. K., Soldatov, V. T., Zhortuylov, O., Әbilzhanұly, T., Uteshev, V. L., Abilzhanov, D. T., Al'shurina, A. S. (2013). Pat. No. 30197 KZ. Sposob prigotovleniya vitaminno-travyanoy muki. No. 2013/0545.1; declareted: 23.04.2013; published: 17.08.2015, Bul. No. 8. Available at: https://kzpatents.com/5-ip30197-sposob-prigotovleniya-vitaminno-travyanojj-muki.html
- Abilzhanov, D. T., Abilzhanuly, T. (2014). Theoretical substantiation of kinematic mode of separator for small leaf part of grass plant. Tractors and agricultural machinery, 7, 32–35. Available at: https://journals.eco-vector.com/0321-4443/article/view/65589
- Abilzhanuly, T., Abilzhanov, D. T. (2020). Determination of the rotation speed of chopped hay on the surface of the separator sieve of the leaf part of herbs. Tractors and agricultural machinery, 4, 53–57. doi: https://doi.org/10.31992/0321-4443-2020-4-53-57
- Abilzhanov, D. T., Abilzhanuly, T., Uteshev, V. L. (2014). Substantiation of parameters of separator for small leaf part of grass plant. Tractors and Agricultural Machinery, 8, 16–19. Available at: https://journals.eco-vector.com/0321-4443/article/view/65529
- Abilzhanuly, T., Abilzhanov, D. T., Uteshev, V. L., Abuғaliev, S. Қ., Shәmshіdіn, Ә. S. (2017). Pat. No. 34143 KZ. Separator dlya listovoy chasti trav iz predvaritel'no izmel'chennogo sena. declareted: 26.09.2017; published: 29.01.2020.
- Abilzhanuly, T., Abilzhanov, D. T., Golikov, V. A., Kalmaғambetov, M. B., Naydenko, E. V. (2019). Substantiation parameters of feeder-dispenser a stem's fodder. Mezhdunarodnaya agroinzheneriya, 3, 35–42. Available at: http://spcae.kz/uploads/jornal/%D0%9C%D0%90-3-2019%20(%D0%BF%D1%80%D0%BE%D0%B2%D0%B5%D1%80%D0%B8%D0%BB).pdf
- Komaristov, V. E., Dunay, N. F. (1971). Sel'skohozyaystvennye mashiny. Moscow: Kolos, 512.
- Bat', M. I., Dzhanamdze, G. Yu., Kel'zon, A. S. (1975). Teoreticheskaya mehanika v primerah i zadachah (statistika i kinematika). Moscow: Nauka, 512.
- Bermant, A. F., Aramanovich, I. G. (2005). Kratkiy kurs matematicheskogo analiza. Sankt-Peterburg: Izd-vo «Lan'», 736.
- Abilzhanuly, T., Abilzhanov, D. T., Golikov, V. A., Smagulov, T. A., Naydenko, E. V., Kalmaғambetov, M. B. et. al. (2020). Tehnologiya i liniya prigotovleniya vitaminno-travyanoy muki iz listovoy chasti trav LVM-0,4: rekomendacii. Almaty: Print-Master, 30.
- Kireev, V. N., Scheglov, V. V., Iglovikov, V. G., Konyushkov, N. S., Movsisyanc, A. P. (1977). Korma. Moscow: Kolos, 368.
##submission.downloads##
Опубліковано
Як цитувати
Номер
Розділ
Ліцензія
Авторське право (c) 2021 Tokhtar Abilzhanuly, Seitkazy Keshuov, Askar Rzaliyev, Omirserik Zhortuylov, Gani Zhumatay, Daniyar Abilzhanov, Darkhan Karmanov, Bauyrzhan Boranbayev

Ця робота ліцензується відповідно до Creative Commons Attribution 4.0 International License.
Закріплення та умови передачі авторських прав (ідентифікація авторства) здійснюється у Ліцензійному договорі. Зокрема, автори залишають за собою право на авторство свого рукопису та передають журналу право першої публікації цієї роботи на умовах ліцензії Creative Commons CC BY. При цьому вони мають право укладати самостійно додаткові угоди, що стосуються неексклюзивного поширення роботи у тому вигляді, в якому вона була опублікована цим журналом, але за умови збереження посилання на першу публікацію статті в цьому журналі.
Ліцензійний договір – це документ, в якому автор гарантує, що володіє усіма авторськими правами на твір (рукопис, статтю, тощо).
Автори, підписуючи Ліцензійний договір з ПП «ТЕХНОЛОГІЧНИЙ ЦЕНТР», мають усі права на подальше використання свого твору за умови посилання на наше видання, в якому твір опублікований. Відповідно до умов Ліцензійного договору, Видавець ПП «ТЕХНОЛОГІЧНИЙ ЦЕНТР» не забирає ваші авторські права та отримує від авторів дозвіл на використання та розповсюдження публікації через світові наукові ресурси (власні електронні ресурси, наукометричні бази даних, репозитарії, бібліотеки тощо).
За відсутності підписаного Ліцензійного договору або за відсутністю вказаних в цьому договорі ідентифікаторів, що дають змогу ідентифікувати особу автора, редакція не має права працювати з рукописом.
Важливо пам’ятати, що існує і інший тип угоди між авторами та видавцями – коли авторські права передаються від авторів до видавця. В такому разі автори втрачають права власності на свій твір та не можуть його використовувати в будь-який спосіб.





