Use of alcoholic waste as cyclohexane oxidation
DOI:
https://doi.org/10.15587/1729-4061.2013.19484Keywords:
waste, cyclohexane, diesel fuel, alcoholic fraction, fusel oil, methane indexAbstract
In the process of cyclohexane oxidation, we obtain a number of side compounds, including alcoholic fraction, which has no target purpose. Accordingly, the topical issue is the further use of alcohol fraction since the division of this mixture into components is a difficult and expensive process, therefore, other methods of recycling and use of this mixture are considered.
Also, in this case it is possible to use such additional alcoholic waste as fusel oil, which has the structure similar to the above given alcoholic fraction, which also has no practical use. One of the possible ways to use the alcoholic fraction (fusel oil) is to add it as an additive to motor fuels as it has long been known that alcohols (in particular, ethanol) are used as additives in the production of fuels.
Accordingly, the use of alcoholic waste as a new source of cetane additives for diesel fuel was proposed, and this method was considered as the possible direction of recycling of alcohol-containing waste of chemical production - fusel oil, alcoholic fraction, which implies the improvement of technoeconomic and environmental performance of production. The positive effect of alcoholic additives on the operational performance of diesel fuel was also established. It was determined that the optimal content of alcoholic additives in diesel fuel is 12 %.
The obtained results indicate the possibility of the use of alcoholic waste as additives to diesel fuel.References
- Белянин, Б. В. Технический аналіз нефтепродуктов и газа [Текст] / Б. В. Белянин, В. Н. Эрих - Л.: «Химия», 1975. - 366 с.
- Robert, L. McCormickAdvancedPetroleumBased [Текст] / L. McCormickRobert, R. M. Parish // MilestoneReport. - 2001. - T. 540 (350). - 22 с.
- Ethanol-DieselBlends [Електронний ресурс], – Доступний зhttp://www.dieselnet.com/tech/fuel_ediesel.php.
- A. P. Sathiyagnanam, Hexanol-Ethanol DieselBlendson DI-Diesel EnginetoStudytheCombustionandEmission [Текст] / A. P. Sathiyagnanam, C. G. Saravananand, M. Gopalakrishnan // International Association of Engineers.-2010.-Т. 155 (117). - 5 с. ISBN: 978-988-18210-7-2.
- Лудин, А. М. Вплив спиртових вiдходiвна якістъ моторних палив [Текст] / А. М. Лудин, В. В. Реутсъкий // Вісник Нац. ун-ту “Лъвiвсъкa політехніка”. Хім1я, технологія речовин i їх застосування. - 2007.–Т. 590. – С. 195-199.
- Іващук, О. С. Вплив спиртiв С2 - С5 на детонаційнівлaстивостi моторних палив [Текст] / О. С. Іващук, А. М. Лудин, В. В. Реутсъкий // Мат-ли 5-г наук.-техн. конф. «Поступ в нафтогазопереробці та нaфтохiмiчнiйпромисловостi. - Лъвiв, червенъ 9-12. - 2009. – С. 122-123.
- Іващук, О. С. Використання відходів виробництва гідролізного спирту [Текст] / О.С. Іващук, А. М. Лудин, В. В. Реутсъкий // Науковий вісник: збірник науково-технічних праць.-НЛТУУ. – 2006. - Вип. Т. 16(3). – С. 105-106.
- E. R. Fanick Fuel and Fuel for Additive Registration Testing Ethsnol-Diesel Blend for O2 Diesel [Текст] / E. R. Fanick //Southwest Research Institute San Antonio. - 2002. - T.-10(1). - 25 с.
- R. L. Cole Effect of Ethanol Fuel Additive on Diesel Emissions [Текст] / R. B. Poola, R. Sekar, J. E. Schaus, P. McPartlin // Center for Transportation Research, Energy Systems Division, Argonne National Laboratory Chicago, Illinois.-2000. - T.-20(11). - 30 с.
- Diesel Engine Efficiency and Emissions Improvement via Piston Temperature Control[Електронний ресурс], - агентство з охорони довкілля США http://cfpub.epa.gov/ncer_abstracts/index.cfm/fuseaction/display.abstractDetail/abstract/10012/report/0.
- Belyanin, B. V, Erich, V. (1975). Technical Analysis of petroleum and gas, 366.
- Robert, L. McCormick and Richard Parish (2001). Advanced Petroleum Based. Milestone Report, 540(350), 22.
- Ethanol-DieselBlends. http://www.dieselnet.com/tech/fuel_ediesel.php.
- Sathiyagnanam, A. P., Saravanan, C.G., Gopalakrishnan, M. (2010). Hexanol-Ethanol Diesel Blends on DI-Diesel Engine to Study the Combustion and Emission.International Association of Engineers, 155(117), 5.
- Ludin, A. M., Reutsky, V. V. (2007). Effect of alcohol on waste quality motor fuels. Forager Nat. University that "Lviv Polytechnic" Chemistry, technology matters and use them, 590, 195-199.
- Іvaschuk, O. S., Ludin, A. M., Reutskyy, V. V. (2009).Effect of alcohol C2 - C5 on waste quality motor fuelson detonatsіynіvlastivosti Engine palivo. Mat-A 5-g-nauk. tehn. conf. "Progress in oil and gas processing industry and oil chemically, 2 122-123.
- Іvaschuk, O. S., Ludin, A. M., Reutskyy, V. V. (2006).The use of waste products hydrolytic alcohol.Research Bulletin: collection of scientific and technical prats.-NLTUU.16(3), 106.
- Fanick, E. R. (2002). Fuel and Fuel for Additive Registration Testing Ethsnol-Diesel Blend for O2 Diesel. Southwest Research Institute San Antonio, 10(1), 25.
- Cole, R. L., Poola, R. B., Sekar, R., Schaus, J. E., McPartlin, P. (2000). Effect of Ethanol Fuel Additive on Diesel Emissions.Center for Transportation Research, Energy Systems Division.Argonne National Laboratory Chicago, Illinois.20(11), 30
- Diesel Engine Efficiency and Emissions Improvement via Piston Temperature Contro. United States Environmental Protection Agency. http://cfpub.epa.gov/ncer_abstracts/index.cfm/fuseaction/display.abstractDetail/abstract/10012/report/0
Downloads
Published
How to Cite
Issue
Section
License
Copyright (c) 2014 Анатолій Миколайович Лудин, Микола Ігорович Кожушко, Віктор Володимирович Реутський
This work is licensed under a Creative Commons Attribution 4.0 International License.
The consolidation and conditions for the transfer of copyright (identification of authorship) is carried out in the License Agreement. In particular, the authors reserve the right to the authorship of their manuscript and transfer the first publication of this work to the journal under the terms of the Creative Commons CC BY license. At the same time, they have the right to conclude on their own additional agreements concerning the non-exclusive distribution of the work in the form in which it was published by this journal, but provided that the link to the first publication of the article in this journal is preserved.
A license agreement is a document in which the author warrants that he/she owns all copyright for the work (manuscript, article, etc.).
The authors, signing the License Agreement with TECHNOLOGY CENTER PC, have all rights to the further use of their work, provided that they link to our edition in which the work was published.
According to the terms of the License Agreement, the Publisher TECHNOLOGY CENTER PC does not take away your copyrights and receives permission from the authors to use and dissemination of the publication through the world's scientific resources (own electronic resources, scientometric databases, repositories, libraries, etc.).
In the absence of a signed License Agreement or in the absence of this agreement of identifiers allowing to identify the identity of the author, the editors have no right to work with the manuscript.
It is important to remember that there is another type of agreement between authors and publishers – when copyright is transferred from the authors to the publisher. In this case, the authors lose ownership of their work and may not use it in any way.
