Improvement of methods of comprehensive assessment of the operation efficiency of centralized heat supply systems in municipal heat power engineering

Authors

DOI:

https://doi.org/10.15587/1729-4061.2021.230218

Keywords:

heat supply system, heat supply modes, central boiler houses, efficiency criterion, efficiency assessment

Abstract

The possibility of a comprehensive assessment of the efficiency of the operation of a district heating system based on the indicator of the overall efficiency of the equipment OEE (overall equipment efficiency) and its extension to the system as a whole is considered. The disunity of the direction of existing approaches in assessing the efficiency of operation of district heating systems does not allow a comprehensive assessment of the overall efficiency of the functioning of the technological sequence of the entire system.

It is proposed to consider efficiency as the probability of full functioning of all elements of the heat supply system.

It is shown that the heat output of the boiler house is proportional to the power consumption of the boiler house and is approximated by a periodic function.

It is shown that the main element of the heat supply system, which determines its efficiency, is the heat-generating source. As a result of the study, it is determined that the efficiency of the heat-generating source functioning increases as the maximum value of its efficiency is reached.

Numerical modeling has shown that the flexible use of the installed heat generator capacity contributes to an increase in the efficiency factor from 0.53 to 0.70 and the overall efficiency of the heat supply system can be increased by more than 30 %. When designing a boiler house, it was recommended to provide for the installation of capacities with gradation 1; 0.5; 0.25.

It is shown that the OEE indicator allows one to characterize the efficiency of both the heat supply system as a whole and its individual components, and can be used in the design and analysis of the operation of systems

Author Biographies

Igor Kozlov, Odessa National Polytechnic University

Doctor of Technical Sciences, Professor

Department of Water and Fuel Technology

Vyacheslav Kovalchuk, Odessа Polytechnic State University

PhD, Associate Professor

Department of Water and Fuel Technology

Oleksandr Klymchuk, Odessа Polytechnic State University

Doctor of Technical Sciences, Professor

Department of Thermal Power Plants and Energy-saving Technologies

Katerina Sova, Odessа Polytechnic State University

Postgraduate Student

Department of Water and Fuel Technology

Inna Aksyonova, Odessa State Academy of Civil Engineering and Architecture

PhD, Associate Professor

Department of Water Supply and Drainage

Krystyna Borysenko, Odessa State Academy of Civil Engineering and Architecture

PhD, Professor

Department of Water Supply and Drainage

References

  1. Zhou, Y., Yu, W., Zhu, S., Yang, B., He, J. (2021). Distributionally robust chance-constrained energy management of an integrated retailer in the multi-energy market. Applied Energy, 286, 116516. doi: https://doi.org/10.1016/j.apenergy.2021.116516
  2. Zhirkova, М. V., Kolodeznikova, A. N. (2017). Performance indicators of the heat supply system’s operational condition. International Research Journal, 1 (55), 67–69. doi: https://doi.org/10.23670/IRJ.2017.55.164
  3. Mazurenko, A., Klimchuk, A., Yurkovsky, S., Omeko, R. (2015) Development of the scheme of combined heating system using seasonal storage of heat from solar plants. Eastern-European Journal of Enterprise Technologies, 1 (8 (73)), 15–20. doi: https://doi.org/10.15587/1729-4061.2015.36902
  4. Zaytsev, O. N., Lapina, E. A. (2017). Increasing the efficiency of the condensing boiler. Journal of Physics: Conference Series, 891, 012158. doi: https://doi.org/10.1088/1742-6596/891/1/012158
  5. Wang, Z., Luo, M., Geng, Y., Lin, B., Zhu, Y. (2018). A model to compare convective and radiant heating systems for intermittent space heating. Applied Energy, 215, 211–226. doi: https://doi.org/10.1016/j.apenergy.2018.01.088
  6. Klymchuk, O., Denysova, A., Balasanian, G., Ivanova, L. (2020). Enhancing efficiency of using energy resources in heat supply systems of buildings with variable operation mode. EUREKA: Physics and Engineering, 3, 59–68. doi: https://doi.org/10.21303/2461-4262.2020.001252
  7. Schlosser, F., Jesper, M., Vogelsang, J., Walmsley, T. G., Arpagaus, C., Hesselbach, J. (2020). Large-scale heat pumps: Applications, performance, economic feasibility and industrial integration. Renewable and Sustainable Energy Reviews, 133, 110219. doi: https://doi.org/10.1016/j.rser.2020.110219 ‏
  8. Pan, E., Li, H., Wang, Z., Peng, D., Zhao, L., Fan, L. et. al. (2020). Operation optimization of integrated energy systems based on heat storage characteristics of heating network. Energy Science & Engineering, 9 (2), 223–238. doi: https://doi.org/10.1002/ese3.842
  9. Klymchuk, O., Denysova, A., Shramenko, A., Borysenko, K., Ivanova, L. (2019). Theoretical and experimental investigation of the efficiency of the use of heat-accumulating material for heat supply systems. EUREKA: Physics and Engineering, 3, 32–40. doi: https://doi.org/10.21303/2461-4262.2019.00901
  10. Bertoldi, P., de Raveschoot, R. P., Paina, F., Melica, G., Janssens-Maenhout, I. G. G. et. al. (2014). How to develop a Sustainable Energy Action Plan (SEAP) in the Eastern Partnership and Central Asian cities. EUR 26741. Luxembourg: Publications Office of the European Union. doi: https://doi.org/10.2790/33989
  11. Savchenko, O., Voznyak, O., Myroniuk, K., Dovbush, O. (2020). Thermal Renewal of Industrial Buildings Gas Supply System. Proceedings of EcoComfort 2020, 385–392. doi: https://doi.org/10.1007/978-3-030-57340-9_47
  12. Ganzha, A. M., Zaiets, O. M., Marchenko, N. A., Kollarov, O. J., Njemcev, E. M. (2018). Methodology of calculation of multiplex heat exchang apparatus with cross flow and mixing in heat carriers. Journal of new technologies in environmental science, 2 (1), 26–35.
  13. Myroniuk, K., Voznyak, O., Yurkevych, Y., Gulay, B. (2020). Technical and Economic Efficiency After the Boiler Room Renewal. Proceedings of EcoComfort 2020, 311–318. doi: https://doi.org/10.1007/978-3-030-57340-9_38
  14. Lutsenko, I. A. (2012). Osnovy teorii effektivnosti. Altaspera Publishing & Literary Agency Inc., 71. Available at: https://ua1lib.org/book/3031189/438b46?id=3031189&secret=438b46
  15. Li, X., Gui, D., Zhao, Z., Li, X., Wu, X., Hua, Y. et. al. (2021). Operation optimization of electrical-heating integrated energy system based on concentrating solar power plant hybridized with combined heat and power plant. Journal of Cleaner Production, 289, 125712. doi: https://doi.org/10.1016/j.jclepro.2020.125712
  16. Rachkov, M. R., Melnikov, V. M. (2017). Development of the method of operational efficiency assessment for centralized heat supply systems in small towns. Vestnik IGEU, 4, 13–20. doi: https://doi.org/10.17588/2072-2672.2017.4.013-020
  17. Ryabtsev, G. A., Ryabtsev, V. I. (2003). Noviy obschiy pokazatel' effektivnosti raboty teploseti. Novosti teplosnabzheniya, 9, 56–59.
  18. Kuznik, I. V. (2011). Otsenka effektivnosti transportirovaniya teplovoy energii. Energosberezhenie, 3, 42–47.
  19. Nakajima, S. (1988). Introduction to TPM: Total Productive Maintenance (Preventative Maintenance Series). Productivity Pr, 129.
  20. De Ron, A. J., Rooda, J. E. (2006). OEE and equipment effectiveness: an evaluation. International Journal of Production Research, 44 (23), 4987–5003. doi: https://doi.org/10.1080/00207540600573402
  21. de Ron, A. J., Rooda, J. E. (2005). Equipment Effectiveness: OEE Revisited. IEEE Transactions on Semiconductor Manufacturing, 18 (1), 190–196. doi: https://doi.org/10.1109/tsm.2004.836657
  22. Morozyuk, L., Sokolovska-Yefymenko, V., Gayduk, S., Moshkatiuk, A. (2018). Entropy­based methods applied to the evaluation of a real refrigeration machine. Eastern-European Journal of Enterprise Technologies, 6 (8 (96)), 49–56. doi: https://doi.org/10.15587/1729-4061.2018.147710
  23. OEE. Available at: https://ru.wikipedia.org/wiki/OEE
  24. Chernousenko, O., Butovsky, L., Rindyuk, D., Granovska, O., Moroz, O. (2017). Analysis of residual operational resource of high-temperature elements in power and industrial equipment. Eastern-European Journal of Enterprise Technologies, 1 (8 (85)), 20–26. doi: https://doi.org/10.15587/1729-4061.2017.92459
  25. Monitoring effektivnosti ispol'zovaniya proizvodstvennogo oborudovaniya. Available at: http://www.up-pro.ru/library/information_systems/toir/monitoring-effektivnosti.html
  26. Narula, K., De Oliveira Filho, F., Chambers, J., Romano, E., Hollmuller, P., Patel, M. K. (2020). Assessment of techno-economic feasibility of centralised seasonal thermal energy storage for decarbonising the Swiss residential heating sector. Renewable Energy, 161, 1209–1225. doi: https://doi.org/10.1016/j.renene.2020.06.099
  27. Klymchuk, A. A., Lozhechnikov, V. F., Mykhailenko, V. S., Lozhechnikova, N. V. (2019). Improved Mathematical Model of Fluid Level Dynamics in a Drum-Type Steam Generator as a Controlled Object. Journal of Automation and Information Sciences, 51 (5), 65–74. doi: https://doi.org/10.1615/jautomatinfscien.v51.i5.60
  28. Zhong, J., Li, Y., Cao, Y., Tan, Y., Peng, Y., Zeng, Z., Cao, L. (2020). Stochastic optimization of integrated energy system considering network dynamic characteristics and psychological preference. Journal of Cleaner Production, 275, 122992. doi: https://doi.org/10.1016/j.jclepro.2020.122992

Downloads

Published

2021-04-30

How to Cite

Kozlov, I., Kovalchuk, V., Klymchuk, O., Sova, K., Aksyonova, I., & Borysenko, K. (2021). Improvement of methods of comprehensive assessment of the operation efficiency of centralized heat supply systems in municipal heat power engineering . Eastern-European Journal of Enterprise Technologies, 2(8 (110), 16–22. https://doi.org/10.15587/1729-4061.2021.230218

Issue

Vol. 2 No. 8 (110) (2021): Energy-saving technologies and equipment

Section

Energy-saving technologies and equipment

License

Copyright (c) 2021 Игорь Леонидович Козлов, Вячеслав Иванович Ковальчук, Александр Андреевич Климчук, Екатерина Александровна Сова, Инна Николаевна Аксёнова, Кристина Игоревна Борисенко

Creative Commons License

This work is licensed under a Creative Commons Attribution 4.0 International License.

The consolidation and conditions for the transfer of copyright (identification of authorship) is carried out in the License Agreement. In particular, the authors reserve the right to the authorship of their manuscript and transfer the first publication of this work to the journal under the terms of the Creative Commons CC BY license. At the same time, they have the right to conclude on their own additional agreements concerning the non-exclusive distribution of the work in the form in which it was published by this journal, but provided that the link to the first publication of the article in this journal is preserved.

A license agreement is a document in which the author warrants that he/she owns all copyright for the work (manuscript, article, etc.).
The authors, signing the License Agreement with TECHNOLOGY CENTER PC, have all rights to the further use of their work, provided that they link to our edition in which the work was published.
According to the terms of the License Agreement, the Publisher TECHNOLOGY CENTER PC does not take away your copyrights and receives permission from the authors to use and dissemination of the publication through the world's scientific resources (own electronic resources, scientometric databases, repositories, libraries, etc.).
In the absence of a signed License Agreement or in the absence of this agreement of identifiers allowing to identify the identity of the author, the editors have no right to work with the manuscript.
It is important to remember that there is another type of agreement between authors and publishers – when copyright is transferred from the authors to the publisher. In this case, the authors lose ownership of their work and may not use it in any way.