Use of fly ash for conditioning the excess activated sludge during deliquefaction at chamber-membrane filter presses
DOI:
https://doi.org/10.15587/1729-4061.2019.170200Keywords:
chamber-membrane filter press, conditioning, fly ash, deliquefaction, filtering duration, activated sludge.Abstract
Results of experimental studies of deliquefaction of excess activated sludge from municipal wastewater treatment facilities in chamber-membrane filter presses were presented. To condition the sludge, fly ash from thermal power plants was added as a mineral additive. Experimental studies have shown high efficiency of deliquefaction of the excess activated sludge with addition of fly ash. Increase in the dose of fly ash has led to an overall increase in filtration capacity and a decrease in moisture content in the filter cake. It was found that in the case of adding fly ash in an amount of 2 wt. % of the initial sludge, deliquefaction efficiency did not increase significantly. In this case, filtering time was reduced only by 15 % and specific capacity increased by 12 %. In the case of increasing the proportion of fly ash to 6 wt. % of initial sludge, a more intensive acceleration of the process was observed. Filtering duration was reduced from 100 to 10 min, specific capacity increased from 87 to 400 l/m2∙hr.
Experimental studies have shown that addition of fly ash to sediments of municipal wastewater treatment facilities as a mineral component provides the possibility of deliquefaction of the suspensions obtained using a chamber-membrane filter press. With optimal doses of 4–5 wt. % of the mass of initial sludge, filter capacity is expected to be 350–400 l/m2∙hr. The resulting filter cake had moisture content of about 60 %, a dense, dry structure making it possible to transport it in bulk.
References
- Sizykh, M. R. (2013). Conditioning of sewage sludge. Vestnik Buryatskogo gosudarstvennogo universiteta, 3, 17–19.
- Wójcik, M., Stachowicz, F., Masłoń, A. (2017). The Possibility of Sewage Sludge Conditioning and Dewatering with the Use of Biomass Ashes. Engineering and Protection of Environment, 20 (2), 153–164. doi: https://doi.org/10.17512/ios.2017.2.1
- Bazzaoui, R., Fraikin, L., Groslambert, S., Salmon, T., Crine, M., Léonard, A. (2011). Impact of Sludge Conditioning on Mechanical Dewatering and Convective Drying. European Drying Conference – EuroDrying'2011, Palma. Balearic Island. Available at: http://www.uibcongres.org/imgdb/archivo_dpo11043.pdf
- Długosz, J., Gawdzik, J. (2014). The Content of Heavy Metals in Sewage Sludge Conditioned CaO. Archives of Waste Management and Environmental Protection, 16 (2), 49–56.
- Zhou, W., Lu, Y., Jiang, S., Xiao, Y., Zheng, G., Zhou, L. (2018). Impact of sludge conditioning treatment on the bioavailability of pyrene in sewage sludge. Ecotoxicology and Environmental Safety, 163, 196–204. doi: https://doi.org/10.1016/j.ecoenv.2018.07.088
- Dieudé-Fauvel, E., Dentel, S. K. (2011). Sludge Conditioning: Impact of Polymers on Floc Structure. Journal of Residuals Science & Technology, 8 (3), 101–108.
- Cao, X., Jiang, Z., Cui, W., Wang, Y., Yang, P. (2016). Rheological Properties of Municipal Sewage Sludge: Dependency on Solid Concentration and Temperature. Procedia Environmental Sciences, 31, 113–121. doi: https://doi.org/10.1016/j.proenv.2016.02.016
- Yang, G. С. С., Lin, C.-K. Effects of Conditioning and Electrokinetics on Sewage Sludge Dewatering. Available at: http://uest.ntua.gr/athens2017/proceedings/pdfs/Athens2017_Gordon_Yang_Lin.pdf
- Lu, Y., Zhang, C., Zheng, G., Zhou, L. (2018). Improving the compression dewatering of sewage sludge through bioacidification conditioning driven by Acidithiobacillus ferrooxidans: dewatering rate vs. dewatering extent. Environmental Technology, 1–14. doi: https://doi.org/10.1080/09593330.2018.1465129
- Wójcik, М., Stachowicz, F., Masłoń, A. (2017). The Evaluation of the Effectiveness of Sewage Sludge Conditioning with the Application of Biomass Ashes. Engineering and Protection of Environment, 20 (3), 295–304.
- Zhvakina, O. A., Gelfand, E. D. (2002). On joint treatment of waste waters sludge of ppm with ash from heat-and-power station. Izvestiya vysshih uchebnyh zavedeniy. Lesnoy zhurnal, 3, 114–121.
- Leont'ev, N. E. (2009). Osnovy teorii fil'tratsii. Moscow: Izd-vo TSPI pri mekhaniko-matematicheskom fakul'tete MGU, 24–29.
- Bahvalov, N. S., Panasenko, G. P. (1984). Osrednenie protsessov v periodicheskih sredah. Moscow: Nauka, 164–169.
- Belyaev, A. Yu. (2004). Usrednenie v zadachah teorii fil'tratsii. Moscow: Nauka, 76–127.
Downloads
Published
How to Cite
Issue
Section
License
Copyright (c) 2019 Oleh Zlatkovskyi, Andrii Shevchenko, Tamara Shevchenko
![Creative Commons License](http://i.creativecommons.org/l/by/4.0/88x31.png)
This work is licensed under a Creative Commons Attribution 4.0 International License.
The consolidation and conditions for the transfer of copyright (identification of authorship) is carried out in the License Agreement. In particular, the authors reserve the right to the authorship of their manuscript and transfer the first publication of this work to the journal under the terms of the Creative Commons CC BY license. At the same time, they have the right to conclude on their own additional agreements concerning the non-exclusive distribution of the work in the form in which it was published by this journal, but provided that the link to the first publication of the article in this journal is preserved.
A license agreement is a document in which the author warrants that he/she owns all copyright for the work (manuscript, article, etc.).
The authors, signing the License Agreement with TECHNOLOGY CENTER PC, have all rights to the further use of their work, provided that they link to our edition in which the work was published.
According to the terms of the License Agreement, the Publisher TECHNOLOGY CENTER PC does not take away your copyrights and receives permission from the authors to use and dissemination of the publication through the world's scientific resources (own electronic resources, scientometric databases, repositories, libraries, etc.).
In the absence of a signed License Agreement or in the absence of this agreement of identifiers allowing to identify the identity of the author, the editors have no right to work with the manuscript.
It is important to remember that there is another type of agreement between authors and publishers – when copyright is transferred from the authors to the publisher. In this case, the authors lose ownership of their work and may not use it in any way.