Impurity distribution during growth of silicon single crystals for solar cells
DOI:
https://doi.org/10.15587/1729-4061.2013.9306Keywords:
silicon, single crystal, effective coefficient of distribution of impurity.Abstract
The article represents the experimental data on the study of the distribution of the main impurities between the liquid and solid phases in the course of growing of the silicon single crystal by the Czochralski method. The mathematical models of the distribution of boron, oxygen, carbon impurities, based on the balance equation of the impurity atoms at each moment of growing, were presented. The main advantage of the developed models is the fact that in their construction, the effective distribution coefficient of impurities is considered as a function of the crystallized fraction of the melt, which is a proxy indicator of the whole complex of technological factors, which vary throughout the process of growing of a single crystal. In addition they do not use physical parameters that can not be measured in specific industrial environments. The suggested models permit to determine the real effective coefficients of distribution of the main impurities, according to the data of the standard quality control of silicon single crystal. The models are used to determine, according to the experimental data of the impurity concentration in the silicon single crystal with a crystalographic orientation <100> and the diameter 100 mm, the values of the effective coefficients of distribution of impurities of boron, oxygen, carbon, at various stages of growing.References
- Проспект фирмы МЕМС, 1994-1995. – 12 с.
- Wijaranacula W. Numerical modeling of the point defect aggregation during the Czochralski silicon crystal growth / W. Wijaranacula // Journal of electrochemical society. – 1992. - Vol. 139, № 2. - P. 604-616.
- Е.Я. Швец. Моделирование распределения примеси бора в процессе выращивания монокристаллов кремния / Швец Е.Я., Головко О.П., Баев В.С., Головко Ю.В. / Металургія. Збірник наукових праць ЗДІА. - Запоріжжя: ЗДІА, 2007. – Вип. 16. – С. 59 – 63.
- Швец Е.Я., Головко Ю.В. Исследование массообмена кислорода в процессе выращивания монокристаллов кремния по методу Чохральского // Теория и практика металлургии, 2008. - № 4-5 (65). – С.3-7.
- Швец Е.Я., Головко Ю.В. Исследование распределения углерода между расплавом, твёрдой и газовой фазами в процессе выращивания монокристаллов кремния / Металургія. Збірник наукових праць ЗДІА. - Запоріжжя: ЗДІА, 2008. – Вип. 17. – С. 104-108.
- F 723. Standard Practice for Conversion Between Resistivity and Dopant Density for Boron-Doped, Phosphorus-Doped, and Arsenic-Doped Silicon // Annual Book of ASTM Standards.Vol.10.05 (1997).
- ASTM F1188. Test method for interstitial atomic oxygen content of silicon by infrared absorption // Annual Book of ASTM Standards.Vol.10.05 (1997).
- ASTM F1391. Standard test method for substitutional atomic carbon content of silicon by infrared absorption // Annual Book of ASTM Standards.Vol.10.05 (1997).
Downloads
Published
How to Cite
Issue
Section
License
Copyright (c) 2014 Юрий Викторович Головко
This work is licensed under a Creative Commons Attribution 4.0 International License.
The consolidation and conditions for the transfer of copyright (identification of authorship) is carried out in the License Agreement. In particular, the authors reserve the right to the authorship of their manuscript and transfer the first publication of this work to the journal under the terms of the Creative Commons CC BY license. At the same time, they have the right to conclude on their own additional agreements concerning the non-exclusive distribution of the work in the form in which it was published by this journal, but provided that the link to the first publication of the article in this journal is preserved.
A license agreement is a document in which the author warrants that he/she owns all copyright for the work (manuscript, article, etc.).
The authors, signing the License Agreement with TECHNOLOGY CENTER PC, have all rights to the further use of their work, provided that they link to our edition in which the work was published.
According to the terms of the License Agreement, the Publisher TECHNOLOGY CENTER PC does not take away your copyrights and receives permission from the authors to use and dissemination of the publication through the world's scientific resources (own electronic resources, scientometric databases, repositories, libraries, etc.).
In the absence of a signed License Agreement or in the absence of this agreement of identifiers allowing to identify the identity of the author, the editors have no right to work with the manuscript.
It is important to remember that there is another type of agreement between authors and publishers – when copyright is transferred from the authors to the publisher. In this case, the authors lose ownership of their work and may not use it in any way.
